Properties of Concrete by Replacement of Natural Sand with ...

The artificial sand have to satisfy the technical requisites such as workability, strength and durability of concrete and hence it has become necessary to study these properties in order to check the suitability and appropriate replacement level of artificial sand in comparison with the natural sand for producing concretes in an economical way ...

اقرأ أكثر

Partial Replacement of Sand with Quarry Dust in Concrete

This present work is an attempt to use Quarry Dust as partial replacement for Sand in concrete. Attempts have been made to study the properties of concrete and to investigate some properties of Quarry Dust the suitability of those properties to enable them to be used as partial replacement materials for sand in concrete.

اقرأ أكثر

Effect of use of Silica Sand as Fine Material in Concrete

Replacement of silica sand in concrete increases from 10% to 70%, the acid cured cube strength was decreases from 4.54% to 20% for mix – 1. For mix -2 the acid cured cube strength was decreases from 6.03% to 16.66% Replacement of silica sand in concrete increases from 10% to 70%, the sulphte cured cube strength was decreases from

اقرأ أكثر

Replacement of Sand with Shredded Plastic in Cement Concrete

Replacement of Sand with Shredded Plastic in Cement Concrete. Vikas Khandelwal. Assistant Professor, Chandigarh University, Mohali, Punjab (India) Abstract The concrete is the second largest material using on earth after water. In India, approximately 400 million metric cube concrete is being used every year and is increasing day by day.

اقرأ أكثر

Suitability of Crushed Manufactured Sand for Replacement ...

The research covered determining the effects of natural sand replacement with manufactured sand of C-25 concrete properties. This experimental study only limited to …

اقرأ أكثر

(PDF) REPLACEMENT OF NATURAL SAND IN CONCRETE BY WASTE ...

Up to 25% of the sand content can be replaced with olive husks to produce reasonable concrete (Bahoria et al. 2013). In 2007, 4.5% of global CO2 emissions (377 million tons of carbon) came from ...

اقرأ أكثر

Partial Replacement of Sand with Sawdust in Concrete

replacement of sand with sawdust in concrete is defined as a composite concrete made with Portland cement, aggregate and fine churns of sawdust. This experimental work is carried out to decide the strength of concrete by adding sawdust as partial replacement …

اقرأ أكثر

Waste plastic could replace sand used in concrete | New ...

18 Sep, 2018 By Katherine Smale. Waste plastic could be used to partially replace sand in concrete to make construction more sustainable, according to research by the University of Bath. The research said it was possible to replace 10% of the sand in a concrete mix with waste plastic which had been ground down to similar sized granules as sand ...

اقرأ أكثر

Effect of replacement of natural sand by artificial sand ...

Title: Effect of replacement of natural sand by artificial sand on strength of concrete ijaerdv04i0688641, Author: Editor IJAERD, Name: Effect of replacement of natural sand by …

اقرأ أكثر

The Effect of Replacement of Natural Sand by Manufactured ...

The natural sand which excavated from river bed is used to produced conventional concrete. Depletion of natural sand cause the environmental problem and hence sand excavating is restricted by government which resulted in shortage and drastically increase in its cost. In order to fulfil the necessity of fine aggregates, an alternative material like M sand can be used in concrete. M …

اقرأ أكثر

Recycling of Waste Glass as Partial Replacement of Sand in ...

The concrete specimens were tested for workability and compressive strength at 7 and 28 days of age and the results obtained were compared with those of normal concrete. The results concluded the acceptability of using waste glass powder as partial replacement of fine aggregates up to 10% by weight for particle size of range 300 micron - 1.18mm.

اقرأ أكثر

ECO-FRIENDLY CONCRETE BY PARTIAL REPLACEMENT OF …

The main objective is to study the replacement of sand by shredded pieces of PET plastic bottles waste in concrete by 0%, 1.0%, 1.5%, 2.0%, 2.5%, 3.0%, 4.0%, 5.0%, 6.0% To investigate the Mechanical properties like Compressive Strength, Split Tensile Strength and …

اقرأ أكثر

(PDF) Strength Characteristics of M40 Grade Concrete using ...

Locally sourced river sand was replaced with industrially ground waste PET in proportions of 4 to 20% at a step of 4% by the weight of natural sand whereas other concrete constituents (cement ...

اقرأ أكثر

203 Partial Replacement of Natural Sand by Microfines for ...

mixes were chosen for natural sand to achieve M25 and M30 grade concrete. The equivalent mixes were obtained by replacing natural sand by stone dust partially and fully. The test results indicate the crushed stone dust waste can be used effectively to replace natural sand in concrete. In the experimental study of strength characteristics of ...

اقرأ أكثر

Effect of replacement of River sand by M-sand in high ...

effect of M -sand as a fine aggregate in high strength concrete and compare the results with the River sand. The scope of the present investigation can be summarized as follows: ¾ To study the effect of workability and the str ength of concrete with the replacement of M -sand by river sand, at an addition of silica fume with cement.

اقرأ أكثر

What are the Materials for Replacement of Sand in Concrete ...

What are the Materials for Replacement of Sand in Concrete? A concrete mix necessarily contents cement, water, fine aggregate and coarse aggregate. Aggregate occupy about 60 – 70% volume of concrete. In this percentage 40 to 50 % proportion of aggregate is fine aggregate (sand).

اقرأ أكثر

Optimization of fully replacement of natural sand by m ...

In recent days the demand for river sand is increasing due to its lesser availability. Hence the practice of replacing river sand with M-Sand is taking a tremendous growth. It is also inferred from the literature that replacement of normal sand with M-Sand produces no appreciable increase in compressive strength due to the variation in the pore size of concrete at micro level.

اقرأ أكثر

(PDF) REPLACEMENT OF NATURAL SAND IN CONCRETE BY …

Up to 25% of the sand content can be replaced with olive husks to produce reasonable concrete (Bahoria et al. 2013). In 2007, 4.5% of global CO2 emissions (377 million tons of carbon) came from ...

اقرأ أكثر

EXPERIMENTAL STUDY ON CONCRETE USING SEA SAND AS …

concrete, 50 and replacement of sea sand with river sand in concrete gives lesser in compressive, ) ) ) IJSER. EXPERIMENTAL STUDY ON CONCRETE USING SEA SAND AS FINE AGGREGATE International Journal of Scientific & Engineering Research Volume 7, Issue 5, May-2016 ...

اقرأ أكثر

An Experimental Study on Partial Replacement of Sand with ...

materials to replace sand. This study aimed to investigate the suitability of using crushed brick in concrete. Crushed brick originated from demolished masonry was crushed in the laboratory and added partial sand replacement. Three replacement levels, 15%,20% and 25%, were compared with the …

اقرأ أكثر

BEHAVIOR OF CONCRETE ON REPLACEMENT OF SAND …

Concrete cube, beam and cylindrical specimens were tested for evaluation of compressive, flexural and split tensile strength respectively. Workability was measured in terms of slump and compacting factor. The concrete exhibits excellent strength with 60% replacement of natural sand, so it can be used in concrete as viable alternative to natural ...

اقرأ أكثر

Waste Plastic a Viable Sand Replacement in Structural Concrete

Plastic waste is a viable partial replacement for sand in structural concrete, according to a new study by researchers from the UK and India. Their findings could help businesses in India dealing with a sand shortage while at the same time addressing the …

اقرأ أكثر

(PDF) EFFECT OF QUARRY DUST AS PARTIAL REPLACEMENT OF SAND ...

Also, the use of quarry dust as the fine aggregate decreases the cost of concrete production in terms of the partial replacement for natural river sand. Design mix of M25grade concrete with ...

اقرأ أكثر

Effects of Copper Slag as Sand Replacement in Concrete

aggregate in concrete. For this research work, m30 grade concrete was used and tests were conducted for various proportions of copper slag replacement with sand of 0 to in concrete. The results demonstrate that up to certain level the strength of concrete increases with …

اقرأ أكثر

Graphite Ore Tailings as Partial Replacement of Sand in ...

In the present investigation, a feasibility study was made for the first time by using graphite ore tailings (GOTS) as a replacement material for river sand in making mortar and concrete. As-received GOTS and treated GOTS (T-GOTS) at 1000°C (1832°F) were replaced with river sand and various percentages of replacement ranging from 10 to ...

اقرأ أكثر

Replacement of Sand with Bauxite Mining Waste in Concrete ...

The use of natural sand as fine aggregate in concrete is becoming problematic due to scarcity and pressure on mining of the resource. Alternate sources such as the use of industrial waste as replacement of natural sand in concrete are gaining popularity as a sustainable construction material.

اقرأ أكثر

Partial replacement of sand by granite powder in concrete

waste can be utilized for the preparation of concrete as partial replacement of sand. In order to explore the possibility of utilizing the granite powder as partial replacement to sand, an experimental investigation has been carried out. The percentages of granite powder added to replace sand by weight were 0, 5, 10, 15, 20 and 25.

اقرأ أكثر

Strength Properties of Concrete Blocks with Sand ...

This study focuses on replacing M Sand with SMS for the development of concrete building blocks. The study evaluates the effectiveness of use of this waste SMS in manufacturing concrete building blocks and estimating its strength properties, keeping a constant workability throughout.

اقرأ أكثر

Reuse of waste iron as a partial replacement of sand in ...

A series of 109 experiments and 586 tests were carried out in this study to examine the feasibility of reusing this waste iron in concrete. Overall, 130 kg of waste iron were reused to partially replace sand at 10%, 15%, and 20% in a total of 1703 kg concrete mixtures.

اقرأ أكثر

Partial Replacement of Sand with Quarry Dust in Concrete

Partial Replacement of Sand with Quarry Dust in Concrete. -The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates …

اقرأ أكثر